Omega Owners Forum

Please login or register.

Login with username, password and session length
Advanced search  

News:

Welcome to OOF

Pages: [1]   Go Down

Author Topic: Some pics of my LPG conversion  (Read 2116 times)

0 Members and 1 Guest are viewing this topic.

Lazydocker

  • Omega Queen
  • *****
  • Offline Offline
  • Gender: Male
  • Woodbridge, Suffolk
  • Posts: 18848
  • Constantly Bullied by a certain Admin
    • View Profile
Some pics of my LPG conversion
« on: 19 August 2008, 20:39:49 »
Unfortunately there aren't as many as I'd like but...

The ECU in position... Not as much room when you've got SL Suspension ::) ::)


The Vaporiser in position and connected... Got to mind the EGR pipes or it'll melt the rubber hoses


ECU connections. Due to the slight lack of wire in the supplied loom (probably more due to the route I took!!) I actually intercepted the required wires just outside the main ECU plug and soldered them there! It was still a tight squeeze getting the plug back on and the ECU into place.


Diagnostic Plug... Nice and accessible :y :y


You can just make out the vaporiser under the airbox... A very tight fit


The LPG pipe... Protected by some old heater hose to ensure there are no snagging points when I have it inspected :y :y (the COP is a bit vague in the description of acceptable risk of damage to pipeline ::) ::)


Pipe and wiring running front to rear



And finally for this instalment... The engine bay now it's all back together :y :y


I'll stick some more up tomorrow after I've finished the back end :y :y :y
« Last Edit: 20 August 2008, 21:41:12 by Lazydocker »
Logged
Whatever it is... I didn't do it

maria

  • Omega Baron
  • *****
  • Offline Offline
  • Gender: Female
  • Derbyshire
  • Posts: 3869
  • I'm proud to be welsh :)
    • View Profile
Re: Some pics of my LPG conversion
« Reply #1 on: 19 August 2008, 21:58:21 »
Good progress....
What's the chances of water ingress with the ECU that low to the ground?
Logged

Lazydocker

  • Omega Queen
  • *****
  • Offline Offline
  • Gender: Male
  • Woodbridge, Suffolk
  • Posts: 18848
  • Constantly Bullied by a certain Admin
    • View Profile
Re: Some pics of my LPG conversion
« Reply #2 on: 19 August 2008, 22:45:19 »
Quote
Good progress....
What's the chances of water ingress with the ECU that low to the ground?

It's not actually as low as it looks... Poor camera skills and bad perspective!!  :-[ :-[ It's actually a good 3 or 4 inches higher than the inner wheel arch :y :y :y

I think it should be OK as long as I don't go through any "puddles" deeper than about 9 inches!!! ::) ::)

Logged
Whatever it is... I didn't do it

Dazzler

  • Omega Baron
  • *****
  • Offline Offline
  • Gender: Male
  • Haverhill, Suffolk
  • Posts: 4198
  • Drive it like you stole it......
    • View Profile
Re: Some pics of my LPG conversion
« Reply #3 on: 21 August 2008, 17:02:30 »
Coming along nicely matey :y
Logged
Big jobbies now finished.....Now running on LPG

Beconboy

  • Intermediate Member
  • ***
  • Offline Offline
  • Gender: Male
  • DAGENHAM
  • Posts: 365
    • 2000 3.0 OMEGA ELITE
    • View Profile
Re: Some pics of my LPG conversion
« Reply #4 on: 21 August 2008, 21:09:38 »
 :ywell done m8 give yaself a pat on the back ;D
Logged

Proz

  • Omega Baron
  • *****
  • Offline Offline
  • Gender: Male
  • Largoward , Fife , Scotland
  • Posts: 2647
    • Omega-less now :-/
    • View Profile
Re: Some pics of my LPG conversion
« Reply #5 on: 21 August 2008, 21:14:44 »
That looks a nice tidy install there .......I think i may look into getting this done in the future  :y
Logged
Get yourself Giff Gaff'ed here :-) ...  http://giffgaff.com/orders/affiliate/proz

Lazydocker

  • Omega Queen
  • *****
  • Offline Offline
  • Gender: Male
  • Woodbridge, Suffolk
  • Posts: 18848
  • Constantly Bullied by a certain Admin
    • View Profile
Re: Some pics of my LPG conversion
« Reply #6 on: 21 August 2008, 21:19:12 »
A few more pictures of the finished conversion :y :y :y

The Filler


... And from the inside


Control switch (sorry for the odd angle!!)


Fill pipe (top) and feed pipe in vent tube


The tank in situ


And finally, the view from the back seats


Calibration is easy and it runs with no noticeable difference in power :y :y :y
Logged
Whatever it is... I didn't do it

humbucker

  • Omega Baron
  • *****
  • Offline Offline
  • Gender: Male
  • Cambridgeshire
  • Posts: 2119
  • VX Trade Card, Halfords Trade Card. Neat.
    • www.irmscherMV6.com
    • View Profile
    • www.irmscherMV6.com
Re: Some pics of my LPG conversion
« Reply #7 on: 21 August 2008, 21:34:06 »
congratulations paul, i'm glad it's all come together for you! any teething problems? looks like a great installation

 :y
Logged
http://www.irmscherMV6.com | #irmscherMV6
Genuine Tech1 and Tech2 diagnostic services for Vauxhalls and Saabs available in and around Cambs.
PM with your requests.

Lazydocker

  • Omega Queen
  • *****
  • Offline Offline
  • Gender: Male
  • Woodbridge, Suffolk
  • Posts: 18848
  • Constantly Bullied by a certain Admin
    • View Profile
Re: Some pics of my LPG conversion
« Reply #8 on: 21 August 2008, 21:41:13 »
Quote
congratulations paul, i'm glad it's all come together for you! any teething problems? looks like a great installation

 :y

Nope... None so far but only really run up and down the road to calibrate it :o :o
Logged
Whatever it is... I didn't do it
Pages: [1]   Go Up
« previous next »
 

Page created in 0.018 seconds with 17 queries.